Barn and shop metal roofs plus shingle repair for Bald Knob properties

Bald Knob takes its name from the bare rock outcrop that once guided travelers across the flat bottomland, and the town still calls itself the place where the Ozarks meet the Delta. To the south and east, rice and soybean fields open up toward the Bald Knob National Wildlife Refuge. To the north, the land starts to roll.

The town was once known as a strawberry capital, and the farming roots show in the property mix. In town you find frame houses, small brick ranches and a few older homes from the railroad era. Out on the county roads, most places have a house plus at least one barn, shop or pole shed.

That means many of our Bald Knob visits cover two very different roofs on the same trip.

Old barn roofs fail in familiar ways. Rusted panels at the eaves where water sits, fasteners whose rubber washers have dried and cracked, and panels lifted at the corners by wind. A shop roof that leaks over a tractor or a workbench costs more in damage every season it waits.

For roofs that are mostly sound, we replace the failed fasteners with new gasketed screws, swap out rusted panels and reseal the ridge and laps. When the steel is thin or rusted through in many places, a full new metal roof is usually the better money.

Ventilation matters in shops too. A closed metal building with no ridge vent or gable louvers collects condensation on the underside of the panels, and that drip can look like a roof leak. We look at airflow before we start replacing panels that are not the real problem.

If you store hay, equipment or a boat in the building, tell us. It changes how we stage the work and whether we can leave part of the roof open overnight.

• Fastener replacement and reseal on a shop roof: often $1,140 to $2,760
• New exposed fastener metal on a 30 by 40 shop: often $6,180 to $10,940
• Pole barn reroof with new purlins where needed: often $8,920 to $18,350

Many houses in town carry shingles that have been patched more than once, sometimes over an older layer. Common repairs include replacing blown off tabs, resealing chimney flashing on older brick homes and fixing porch roof tie-ins where the low slope meets the main roof.

Low-slope porch and carport roofs are a frequent leak source here. Shingles on a pitch that flat do not shed water well, and we often recommend converting those sections to a proper low-slope membrane or metal while the rest of the house keeps its shingles.

Chimney leaks on older brick homes are common here too. Mortar crumbles, the counterflashing pulls loose, and water runs down inside the chimney chase. We reflash with new step and counterflashing and reset it into a fresh mortar joint.

Storms that build over the Delta have miles of open ground to cross before they reach a Bald Knob roof. Straight-line winds in spring and early summer peel back shingle edges, lift metal panels at the gable ends and send loose sheet metal from one property onto another.

Tornadoes are part of the local history too. A March 1952 tornado destroyed much of the school campus. After a storm, we photograph every lifted panel and creased shingle, which helps if you file a claim, and we secure open areas before a second round of rain.

Ice storms are less common, but they do happen. Ice weighs down limbs, fills gutters and can pull weak gutter brackets loose from soft fascia boards.

Bald Knob is about an hour from our downtown Little Rock office, at the point where US 167 splits off toward Batesville. We schedule visits rather than promising same-hour arrival, and we often pair Bald Knob jobs with work in Searcy and Beebe on the same day.

Call (501) 387-1152 and tell us what needs attention, both house and outbuildings. We measure everything on one visit and give you a written price before any work starts. When we finish, we clean up and run a magnet sweep for nails, including around barn doors and gravel drives where tires roll.